Product ID:30821 OATEY ALL PURPOSE CEMENT
MSDS Date:05/28/1997
FSC:8040
NIIN:00F041843
Status Code:A
MSDS Number: CKRBF

OATEY CO

4700 WEST 160TH STREET
CLEVELAND, OH 44135
US

Emergency Phone: 303-623-5716 COLLECT

Info Phone: 216-267-7100

Cage: 53472

OATEY CO

35906 CLEVELAND, OH 44135 US

Telephone: 216-267-7100/303-623-5716

Cage: 53472

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/CUM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

AMORPHOUS SILICA

CAS: 112945-52-5

RTECS: VV7310000

OSHA PEL 20 MPPCF

ACGIH TLV: 10 MG/CUM

CHLORINATED POLYVINYL CHLORIDE, CPVC RESIN (NON HAZARDOUS)

CAS: 68648-82-8

RTECS: FO1930000

POLYVINYL CHLORIDE, PVC RESIN (NON HAZARDOUS)

CAS: 9002-86-2

RTECS: KV0350000

CYCLOHEXANONE

CAS: 108-94-1

RTECS: GW1050000

OSHA PEL 50 PPM

ACGIH TLV: 100 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TETRAHYDROFURAN

CAS: 109-99-9

RTECS: LU5950000

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: IRRITATION OF MUCOUS
MEMBRANES, NOSE & THROAT. SKIN: IRRITATION & DERMATITIS, MAY
POSSIBLY BE ABSORBED THROUGH THE SKIN. EYES: IRRITATION. INGESTION:
MAY BE ASPIRATED INTO THE LUNGS/CAUSE SYSTEM EFFECTS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, NAUSEA,
NUMBNESS OF THE EXTREMITIES, NARCOSIS.

First Aid:SKIN: WASH THOROUGHLY W/SOAP & WATER. EYES: REMOVE TO FRESH
AIR & FLUSH W/WATER FOR 15 MINS. INHALATION: REMOVE TO FRESH AIR.
GIVE OXYGEN/CPR IF NEEDED. KEEP QUIET & WARM. INGESTION: DRINK
WATER. AVOI D ALCOHOLIC BEVERAGES. NEVER GIVE ANYTHING BY MOUTH IF
UNCONSCIOUS. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:PMCC
Flash Point:0-5F
Lower Limits:1.8
Upper Limits:11.8
Extinguishing Media:SMALL: DRY CHEMICAL, CO2, WATER/FOAM. LARGE:
EVACUATE AREA & CALL FIRE DEPARTMENT IMMEDIATELY.
Fire Fighting Procedures:EVACUATE AREA.

Spill Release Procedures:VENTILATE AREA, STOP LEAK SAFELY W/O RISK.
TAKE UP W/SAND, EARTH/OTHER NON-COMBUSTIBLE ABSORBING MATERIAL.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
STORE IN COOL, DRY PLACE. CONTAINERS EVEN EMPTIES WILL RETAIN
RESIDUE & VAPORS.

Respiratory Protection:USE NIOSH-APPROVED CANNISTER RESPIRATOR IN
ABSENCE OF ADEQUATE VENTILATION.
Ventilation:GENERAL MECHANICAL: TO MAINTAIN EMISSIONS BELOW PEL. LOCAL
EXHAUST: OPEN DOORS/WINDOWS. ENCLOSED AREA, USE EXHAUST FANS.
Protective Gloves:RUBBER
Eye Protection:SAFETY GLASSES W/SIDE SHIELDS
Other Protective Equipment:EYE WASH & SAFETY SHOWER
Supplemental Safety and Health
FLAMMABLE LIQUID, LIQUID WILL DISSOVLE IN TETRAHYDROFURAN. ONE THF
VENDOR HAS RECOMMENDED A REDUCTION IN THE ACCEPTABLE EXPOSURE LIMIT
FROM 200 PPM TO 25 PPM, 8 & 12 HR TWA.

Boiling Pt:=66.1C, 151.F
Vapor Pres:145 MMHG @ 2 0 C
Vapor Density:2.5
Spec Gravity:0.90 +/- 0.02
Evaporation Rate & Reference:(BU AC = 1): 5.5-8
Solubility in Water:NEGLIGIBLE
Appearance and Odor:MILKY LIQUID W/ETHER-LIKE ODOR
Percent Volatiles by Volume:84 - 88

Stability Indicator/Materials to Avoid:YES
ACIDS/OXIDIZING MATERIALS/ALKALIS/CHLORINATED INORGANICS (POTASSIUM,
CALCIUM/SODIUM HYPOCHLORITE)COPPER/COPPER ALLOYS.
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME
Hazardous Decomposition Products:CO, CO2, HYDROGEN CHLORIDE/SMOKE

Waste Disposal Methods:DISPOSE OF IAW/LOCAL, STATE & FEDERAL
REGULATIONS. EPA HAZARDOUS WASTE D001, IGNITABLE WASTE/TOXIC WASTE.

Toxicological Information:TARGET ORGANS: KIDNEY, NERVOUS SYSTEM, LUNG,
LIVER, EYE, SKIN. TOXIC AGENT, REPRODUCTIVE TOXIN, IRRITANT, SKIN
& EYE HAZARD. NTP HAS REPORTED THAT EXPOSURE OF MICE & RATS TO
TETRAHYDROFURAN (THF) VAP OR LVELS UP TO 1800 PPM 6HR/DAY 5
DAYS/WEEK FOR THEIR LIFETIME CAUSED AN INCREASED INCIDENCE OF
KIDNEY TUMORS IN MALE RATS & LIVER TUMORS IN FEMALE MICE. THE
SIGNIFICANCE OF THESE FINDINGS FOR HUMAN H EALTH ARE UNCLEAR AT
THIS TIME, & MAY BE RELATED TO SPECIES SPECIFIC EFFECTS. ELEVATED
INCIDENCES OF TUMORS IN HUMANS HAVEN'T REPORTED FOR THF.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:DOT SHIPPING NAME: CONSUMER COMMODITY ORM-D

SARA Title III Information:SEC 313: METHY ETHYL KETONE
Federal Regulatory Information:EPA HAZARD WASTE ID NUMBER D001, HAZARD
WASTE CLASS: IGNITABLE WASTE/ TOXIC WASTE